Day 205, Fixed windows trim frames, finishing AC cabinet, 12V outlets installation, several small things complete.
Day 206, New Fixed windows trim installation.
Interior (small things)
Fixed windows
New trim around fixed windows made out of teak and installed. each trim piece made of 4 parts. all cut on my workshop CNC out of teak wood. Only thing left here - paint the gap between window and trim.
Other things done today
Made and installed Door-cover under the AC inlet.
LPG sensor - alarm installed.
I installed the alarm ind found it is alarming all time. I am pretty sure I have no LPG on the board. I bought the sensor several years ago, and it was on the boat all the time and likely was "poisoned" by paint thinners fumes. Ordering a replacement.
Other small things
Replaced engine overheat dumb lamp fixture (original had rubber disintegrated) .
In attempt to tight engine (ignition) switch I broke it, by break line it was cracked for a while. Good to get it broken at the dock ;-)
Connected compass light back, added connector for convenience.
Investigated steering cross member, confirmed there no life threatening cracks on it.
Checked dorade box to estimate how to make wter separation wall there, found wasps nest ;-)
Replaced shore line GFCI breaker to 32A - 30mA version. Ip67 box cannot cose properly, need to find dipper box or make spacier.
Installed x3 12V outlets (mainly for 12v fans):
starboard - in between galley and settee (+with USB charger),
port - on the nav station from the side of shelves.
Port - in the head.
Interior work officially "almost done". But some imperfection left for future.
Interior imperfections listing
Some of them I will leave for future, some just leave as is.
Chain plates - headliner connection need trim plate
 |
| Starboard chainplate. |
 | |
| Port side chainplate |
Portside open shelves headliner to back liner connection has gap about 1/2 inch. also stanchion mounting block is not covered or even pained. Headliner to nav station connection needs trim.
 | |
| Portside shelves, stanchion block |
 | ||
| Portside shelves, headliner |
Other thing, gelcoat on the bottom shelf is damaged and stained.
Galley - gap between back liner and cabinet wall.
Galley cabinets, minor paint damages.
Nav station, gap between panels, need backer plate to hide shiny thermal insulation.
Wall next to compression post needs detail painting.
Headliner connections are asking for trim
Head door needs sloped plank to let water drip into the shower pan if some water will try to run out.
